CRJ-200 飞机航线维护工作单—航后

民航

游客，如果您要查看本帖隐藏内容请回复

民航

CRJ-200 飞机航线维护工作单—航后
CRJ-200 AIRCRAFT LINE MAINTENANCE CHECK LIST —AFT-FLIGHT
工作日期
DATE
维修单位
EXECUTIVE UNIT
航班号
FLIGHT NO.
地点
STATION
飞机注册号
AIRCRAFT REG.NO.
放行者签字
DISPATCHED BY
总工时
TOTAL MANHOURS
120分钟/MIN
项目
Item
工作 内 容
Task Description
工作者
Operator
修正号
REV. NO. 05
校正日期
REV. DATE
2006.07.20 页号
PAGE NO.
第 1 页共 6 页
东航云南分公司昆明机务办公室制定
1.0 机电外部检查 ME Exterior Check 工时/MH：40 分钟/MIN
1.01 左前机身 Left Forward Fuselage
(1) 从地面上目视检查驾驶舱窗户和结构、风挡雨刮、结冰探头、登机门应无损伤
且状况良好。
Do a visual check as seen from the ground for damage and for the condition
of the items that follows: flight compartment windows and frames, window
wipers, ice detector, passenger/crew door.
1.02 前轮舱 Nose Hydraulic Compartment
(1) 目视检查前起落架应无液体渗漏且状况良好，舱门无损坏（参考AMM TASK
32-20-00-210-801）。
Do a visual check for fluid leakage and the condition of the nose landing
gear and for damage to the doors.
(2) 目视检查前机轮/轮胎组件的损伤和磨损状况（参考AMM TASK
32-42-01-210-801）。
Do a visual check of the nose wheel/tire assemblies for damage and wear.
(3) 用干净布沾液压油(MIL-H-5606)清洁前起落架镜面并擦干。
Clean the nose landing gear piston with a clean cloth moistened with
hydraulic fluid (MIL-H-5606) and rub with a clean dry cloth.
1.03 左中前部机身 Left Mid-Forward Fuselage
(1) 目视检查左中前部机身和客舱玻璃应无损伤且状况良好。
Do a visual check for damage and the condition of the left mid-forward
fuselage and the cabin windows.
1.04 左主起落架 Left Main Landing Gear
(1) 目视检查左主起落架应无液体渗漏且状况良好，舱门无损坏（参考AMM TASK
32-10-00-210-801）。
Do a visual check for fluid leakage and the condition of the left main landing
gear and for damage to the door.
(2) 目视检查左主起落架机轮/轮胎组件的损伤和磨损状况（参考AMM TASK
32-41-01-210-801）。
Do a visual check of the left main landing gear wheel/tire
assemblies for damage and wear.
(3) 详细检查左主起落架刹车指示销的磨损状况：设置停留刹车，确信刹车磨损指
示杆未磨平（参考AMM TASK 32-43-26-210-801）。
Do a detailed inspection of the left main landing gear brake wear pin
indicators. Set parking brake, make sure that the end of the wear indicator
pin is not flat with, or below, the surface of the housing bracket.
(4) 用干净布沾液压油(MIL-H-5606)清洁主起落架镜面并擦干。
Clean the main landing gear piston with a clean cloth moistened with
hydraulic fluid (MIL-H-5606) and rub with a clean dry cloth.
CRJ-200 飞机航线维护工作单—航后
CRJ-200 AIRCRAFT LINE MAINTENANCE CHECK LIST —AFT-FLIGHT
项 目
Item
工作 内 容
Task Description
工作者
Operator
修正号
REV. NO. 05
校正日期
REV. DATE
2006.07.20 页号
PAGE NO.
第 2 页共 6 页
东航云南分公司昆明机务办公室制定
1.05 左机翼 Left Wing
(1) 目视检查前缘和翼上加油口盖(1处)应无损伤、渗漏且状况良好。
Do a visual check for damage, leakage and the condition of the leading
edges and the overwing filler cap (1 place).
(2) 清洁左机翼前缘（参考AMM TASK 57-41-01-110-801或57-41-01-110-803）。
Clean left wing leading edge.
(3) 目视检查翼尖小翼、油箱通气口和飞行操纵面的状况。
Do a visual check for the condition of the winglet, NACA scoop and the flight
control surfaces.
(4) 一般目视检查各放油口应无液体渗漏（左主和中央油箱）（参考AMM TASK
28-11-00-210-803）。
Do a general visual check of the fuel and water drain valves for fuel leakage
(left main and center fuel tank).
(5) 操作检查燃油箱释压活门（左主和中央油箱）：拉出释压活门手柄，确信活门
开关正常。
Do an operational check of the fuel tank pressure relief valves (left main and
center fuel tank). Pull the handle of the relief valve. Make sure that the valve
opens and closes.
1.06 左中后部机身 Left Mid-Aft Fuselage
(1) 从地面上目视检查机身区域、客舱玻璃、翼上应急出口、各入口盖板、APU进
气口、APU冷却气入口、空调排气口和货舱门应无损伤且状况良好。
Do a visual check as seen from the ground for damage and the condition of
the items that follow: fuselage area, cabin windows, overwing emergency
exit, access panels, APU inlet, APU cooling inlet, air conditioning exhaust,
cargo door.
(2) 检查货舱内部地板、侧壁板、天花板无损坏，结构及栏网完好并清洁。对前货
舱和货舱门框进行目视检查，发现脏物及时清洁，特别是由于装化学制品、
海鲜、家禽等货物后，如有液体溢出应立即彻底清除。
Inspect the floor, side wall, ceiling of cargo for damage, and make sure the
structure and block net are clean. Visually inspect fwd cargo compartment
and doorframe. Clean dirty contamination. Specially pay attention to
chemical products, seafood, poultry etc. Clean it entirely at once if liquid
flows out.
1.07 左发动机 Left Engine
(1) 目视检查进气区域和第一级风扇叶片组件、整流锥、整流罩、各接近盖板、排
放口、排放罩、锁销和排气尾喷应无损伤、渗漏且状况良好。
Do a visual check for damage, leakage, and the condition of the items that
follow: intake area and first stage fan blade assembly, spinner, cowls,
access panels, drains, drain mast, latches, exhaust nozzle.
1.08 后设备舱 Aft Equipment Compartment
(1) 发动机关车3分钟到2小时之间，勤务发动机滑油（左和右发动机）（参考AMM
TASK 12-13-79-612-802），在飞行记录本上记录添加的滑油量。
Between 3 minutes and 2 hours after the engine has been shutdown,
service engine oil tank (left and right engine), write in the flight logbook the
quantity of engine oil added to.
(2) 勤务滑油补充油箱（参考AMM TASK 12-13-79-612-802）。
Service the oil replenishment tank.
CRJ-200 飞机航线维护工作单—航后
CRJ-200 AIRCRAFT LINE MAINTENANCE CHECK LIST —AFT-FLIGHT
项 目
Item
工作 内 容
Task Description
工作者
Operator
修正号
REV. NO. 05
校正日期
REV. DATE
2006.07.20 页号
PAGE NO.
第 3 页共 6 页
东航云南分公司昆明机务办公室制定
1.09 尾部 Empennage
(1) 从地面上目视检查垂直安定面、方向舵、尾锥、水平安定面、升降舵应无损伤
且状况良好。
Do a visual check as seen from the ground for damage and the condition of
the items that follow: vertical stabilizer, rudder, tailcone, horizontal stabilizer,
elevators.
1.10 右发动机 Right Engine
(1) 目视检查进气区域和第一级风扇叶片组件、整流锥、整流罩、各接近盖板、排
放口、排放罩、锁销和排气尾喷应无损伤、渗漏且状况良好。
Do a visual check for damage, leakage, and the condition of the items that
follow: intake area and first stage fan blade assembly, spinner, cowls,
access panels, drains, drain mast, latches, exhaust nozzle.
1.11 右中后部机身 Right Mid-Aft Fuselage
(1) 从地面上目视检查机身区域、客舱玻璃、翼上应急出口、各勤务和入口盖板、、
APU排气口和空调排气口应无损伤且状况良好。
Do a visual check as seen from the ground for damage and the condition of
the items that follow: fuselage area, cabin windows, overwing emergency
exit, service and access panels, APU exhaust, air conditioning exhaust.
1.12 右机翼 Right Wing
(1) 目视检查前缘和翼上加油口盖(2处)应无损伤、渗漏且状况良好。
Do a visual check for damage, leakage and the condition of the leading
edges and the overwing filler cap (2 place).
(2) 清洁右机翼前缘（参考AMM TASK 57-41-01-110-801或57-41-01-110-803）。
Clean right wing leading edge.
(3) 目视检查翼尖小翼、油箱通气口和飞行操纵面的状况。
Do a visual check for the condition of the winglet, NACA scoop and the flight
control surfaces.
(4) 一般目视检查燃油加油盖板和各放油口应无液体渗漏（右主油箱）（参考AMM
TASK 28-11-00-210-803）。
Do a general visual check of the fuel access panels and fuel and water drain
valves for fuel leakage (right main fuel tank).
(5) 操作检查燃油箱释压活门（右主油箱）：拉出释压活门手柄，确信活门开关正
常。
Do an operational check of the fuel tank pressure relief valves (right main
fuel tank). Pull the handle of the relief valve. Make sure that the valve opens
and closes.
CRJ-200 飞机航线维护工作单—航后
CRJ-200 AIRCRAFT LINE MAINTENANCE CHECK LIST —AFT-FLIGHT
项 目
Item
工作 内 容
Task Description
工作者
Operator
修正号
REV. NO. 05
校正日期
REV. DATE
2006.07.20 页号
PAGE NO.
第 4 页共 6 页
东航云南分公司昆明机务办公室制定
1.13 右主起落架 Right Main Landing Gear
(1) 目视检查右主起落架应无液体渗漏且状况良好，舱门无损坏（参考AMM TASK
32-10-00-210-801）。
Do a visual check for fluid leakage and the condition of the right main
landing gear and for damage to the door.
(2) 目视检查右主起落架机轮/轮胎组件的损伤和磨损状况（参考AMM TASK
32-41-01-210-801）。
Do a visual check of the right main landing gear wheel/tire assemblies for
damage and wear.
(3) 详细检查右主起落架刹车指示销的磨损状况:设置停留刹车，确信刹车磨损指示
杆未磨平（参考AMM TASK 32-43-26-210-801）。
Do a detailed inspection of the right main landing gear brake wear pin
indicators. Set parking brake, make sure that the end of the wear indicator
pin is not flat with, or below, the surface of the housing bracket.
(4) 用干净布沾液压油(MIL-H-5606)清洁主起落架镜面并擦干。
Clean the main landing gear piston with a clean cloth moistened with
hydraulic fluid (MIL-H-5606) and rub with a clean dry cloth.
1.14 右中前机身 Right Mid-Forward Fuselage
(1) 目视检查右中前部机身、客舱玻璃、加油/抽油口和各入口盖板应无损伤且状况
良好，
Do a visual check for damage and the condition of the right mid-forward
fuselage, cabin windows and the refuel/defuel adapter and access panel.
1.15 右前机身 Right Forward Fuselage
(1) 从地面上目视检查勤务门、结冰探头应无损伤且状况良好。
Do a visual check as seen from the ground, for damage and for the condition
of the items that follows: galley service door, ice detector.
(2) 目视检查氧气释放指示器应在位。
Do a visual check of the oxygen discharge indicator and make sure that it is
there.
(3) 目视检查机组氧气系统压力正常并按需勤务（参考AMM TASK
12-16-35-614-801）。
Do a visual check of the quantity level of the crew oxygen system and
service as necessary.
2.0 机电驾驶舱检查 ME Cockpit Check 工时/MH：15 分钟/Min
2.01 查阅并处理客舱和技术记录本记录的故障。
Review the cabin log and technic log, and properly handle the recorded
problems.
2.02 检查适航证、国籍登记证和电台执照应在位。
Make sure that the Standard Airworthiness Certificate, the Certificate of Civil
Aircraft Registration and the Aircraft Station License are in position.
2.03 查阅EICAS 各页面。
Review all EICAS pages.
2.04 操作检查着陆/滑行灯、频闪灯、位置灯、防撞灯、机翼检查灯、标志灯、翼上应急
灯、货舱照明灯应工作正常。
Do an operational check of the external lights that follow: landing /taxi, strobe,
position, anti-collision, wing inspection, logo, overwing emergency exit, cargo
door illumination.
CRJ-200 飞机航线维护工作单—航后
CRJ-200 AIRCRAFT LINE MAINTENANCE CHECK LIST —AFT-FLIGHT
项 目
Item
工作 内 容
Task Description
工作者
Operator
修正号
REV. NO. 05
校正日期
REV. DATE
2006.07.20 页号
PAGE NO.
第 5 页共 6 页
东航云南分公司昆明机务办公室制定
2.05 操作检查驾驶舱内所有灯光工作正常，各电门、跳开关位置正常。
Do an operational check of all lights, make sure all switches and circuit breakers
are in normal position.
2.06 检查应急设备：消防斧头(1 处)、驾驶舱逃离绳(1 处)、防火手套(1 处)、防烟罩(1
处)和手提灭火瓶(1 处)应完好在位。
Make sure that all the emergency equipments such crash axe(1 place), flight
compartment escape rope (1 place), gloves(1 place), PBE(1 place) and portable
fire extinguishers(1 place) are in place and good condition.
2.07 检查1、2和3号液压系统的液压油量（参考AMM TASK 12-12-29-611-803）。
Do a check of the fluid level of hydraulic systems No. 1, 2 and 3.
3.0 机电客舱检查 ME Cockpit Check 工时/MH：10 分钟/Min
3.01 检查厕所/厨房的机械/电气设备。
Check mechanical/electrical devices of lavatory/galley.
3.02 操作检查客舱内部灯光、机内外应急灯。
Operationally check the cabin interior lights and the interior and exterior
emergency lights.
3.03 检查应急设备：翼上逃离绳(2 处)、防烟罩(2 处)、应急手电(4 处)、应急喇叭(1 处)、
急救箱及封条(1 处)、药箱及封条(1 处)、手提氧气瓶(2 处)、手提灭火瓶(2 处)、厕
所灭火瓶(1 处) 和应急程序操作卡(2 处)应完好在位。
Make sure that all the emergency equipments such as emergency exit escape
rope (2 place), PBE(2 place), flashlights(4 place), emergency megaphones(1
place), first aid kit and its seal(1 place), medical kit and its seal(1 place), portable
oxygen bottles(2 place), portable fire extinguishers(2 place), lavatory fire
extinguishers(1 place) and emergency procedure handling card(2 place) are in
place and good condition.
4.0 电子外部检查 AV Exterior Check 工时/MH： 10 分钟/MIN
4.01 左前机身 Left Forward Fuselage
(1) 从地面上目视检查雷达罩、静压口、皮托静压管、备用静压管、导航/通信天线
应无损伤且状况良好。
Do a visual check as seen from the ground, for damage and for the condition
of the items that follows: radome, static port, pitot static head, standby pitot
tube, navigation/communication antennae.
4.02 左机翼 Left Wing
(1) 目视检查机翼放电刷(6根)的状况。
Do a visual check of the wing static dischargers (6 place) for condition.
4.03 尾部 Empennage
(1) 从地面上目视检查放电刷(3013/3019/3021/3070为12根，3071为14根)应无损
伤且状况良好。
Do a visual check as seen from the ground for damage and the condition of
static dischargers(3013/3019/3021/3070:12 place, 3071:14 place).
4.04 右机翼 Right Wing
(1) 目视检查机翼放电刷(6根)的状况。
Do a visual check of the wing static dischargers (6 place) for condition.
4.05 右前机身 Right Forward Fuselage
(1) 从地面上目视检查静压口、皮托静压管、TAT探头应无损伤且状况良好。
Do a visual check as seen from the ground, for damage and for the condition
of the items that follows: static port, pitot static head, tat probe.
CRJ-200 飞机航线维护工作单—航后
CRJ-200 AIRCRAFT LINE MAINTENANCE CHECK LIST —AFT-FLIGHT
项 目
Item
工作 内 容
Task Description
工作者
Operator
修正号
REV. NO. 05
校正日期
REV. DATE
2006.07.20 页号
PAGE NO.
第 6 页共 6 页
东航云南分公司昆明机务办公室制定
5.0 电子驾驶舱检查 AV Cockpit Check 工时/MH：15 分钟/Min
5.01 查阅并处理客舱和技术记录本记录的故障。
Review the cabin log and technic log, and correct the recorded faults.
5.02 操作测试TCAS系统（参考AMM TASK 34-43-00-710-801）。
Do an Operational test of TCAS.
5.03 操作测试飞行记录器（参考AMM TASK 31-31-01-710-801）。
Do an Operational test of flight data recorder.
5.04 操作测试话音记录器（参考AMM TASK 23−71−00−710−801）。
Do an Operational test of cockpit voice recorder.
5.05 功能测试时钟系统（参考AMM TASK 31−21−00−720−801）。
Do a functional test of the clock system.
5.06 清洁主仪表板、中央操纵台面板。
Clean the main instrument panel and central control stand.
5.07 检查电子设备应完好，各电门在正常位。
Check the electronic equipments for condition, make sure all switches are in the
normal position.
6.0 结束项目 Close-up Items 工时/MH：30 分钟/Min
6.01 装好各罩布、起落架地面安全销、接地线、ADG 地面安全销和空速管套。
Install all the shrouds, landing gear ground safety pins, ground cable, ADG
ground safety pins and static heads covers
6.02 如果外界温度低于零度，在航后飞机落地1 小时后对各燃油箱所有放油口实施放油
检查。（并且在该栏签字）
If ambient temperature is below zero centigrade, operationally check all water
drain valves of fuel tanks to collect water or contaminants after more than 1 hours
of aircraft landing. ( sign the appropriate items if done )
外界温度（ambient temperature）： ___________ºC
6.03 在寒冷天气时，确信饮用水系统和污水箱已排放。
In freezing conditions, make sure the potable water system and the toilet waste
tanks have been drained.
6.04 更换QAR磁光盘（本项工作仅适用于基地站的航后）。
Replace the QAR disk (This item is applicable to the aircraft parking at the
maintenance base)。
6.05 在技术记录本上记录纠正措施并针对每个纠正的或完成的项目签字.
Endorse corrective actions in technical log book and sign against each corrected or
carried forward item.
6.06 确认放行人员放行飞机。
Make sure authorized person releases the aircraft.

bocome

CRJ-200 飞机航线维护工作单—航后